HUDSON-ESSEX. COACH and ESSEX SEDAN BODY PARTS LIST. Hudson Motor Car Company DETROIT, MICHIGAN. Hudson-Built Bodies.

Transcription

1

2 HUDSON-ESSEX COACH and ESSEX SEDAN BODY PARTS LIST Hudson-Built Bodies December, 9 Hudson Motor Car Company DETROIT, MICHIGAN

3

4 INDEX PARTS GROUPS FRONT SECTION Hudson Coach Essex Coach Essex Sedan Cowl and Dash Cowl Ventilator Front Pillar and Windshield Panels Instrument Panel Windshield Windshield Visor CENTER SECTION Center Pillar (Sedan) Door Assembly Door Check (Sedan) Door Dovetail and Bumper Door Finish Strip Door Glass and Channels Door Hinge Door Lock Door Weatherstrips and Trim Retainers Door Windlace Door Window Regulator REAR SECTION Hinge and Quarter Pillars (Coach) Outside Panels and Mouldings Quarter Glass and Channels Quarter Window Weatherstrips and Trim Retainers Quarter Window Frame and Curtains Quarter Window Regulator Rear Hinge Pillar (Sedan) Rear Upholstery Panels Rear Window TOP SECTION Dome Light Roof.. 9 FLOOR SECTION Carpets, Mats and Pads Scuff Plate Seats and Cushions Toe and Floor Boards Hudson Coach Essex Coach Essex Sedan (front section) Essex Sedan (center section) Essex Sedan (rear section) ILLUSTRATIONS pages 5 and pages 5 and page page page 7

5 HUDSON COACH BODY PARTS LIST HUDSON COACH BODY PARTS LIST Hudson Motor Car Company Detroit, Michigan Repair Parts stocks are maintained by Essex and Hudson dealers in more than twenty-five hundred principal cities and owners are urged to avail themselves of this service when it is required. In addition, large complete stocks are maintained in the following cities. Where desired, orders can be sent to any of these cities, either by telegraph, telephone, or mail, addressed simply to "The Hudson-Essex Distributor" and prompt shipment will be obtained: Albany, N. Y. Hartford, Conn. Portland, Maine Amarillo, Te x as Hastings, Neb. Portland, Oregon Asheville, N. C. Houston, Te x as Providence, R. I. Atlanta, Ga. Baltimore, Md. Hutchinson, Kan. Indianapolis, Ind. Reno, Nevada Richmond, Va. Bangor, Maine Jackson, Miss. Roanoke, Va. Billings, Mont. Jacksonville' Fla. Rochester, N. Y. Birmingham, Ala. Johnstown, Penn. Saginaw, Mich. Boise, Idaho Boston, Mass. Kalamazoo, Mich. Kansas City, Mo. Salina, Kan. Salt Lake City, Utah Brattleboro, Vt. Kno x ville, Tenn. San Antonio, Te x as Bridgeport, Conn. Laurinburg, N. C. San Francisco, Cal. Buffalo, N. Y. Lincoln, Nebr. Seattle, Wash. Butte, Mont. Charleston, W. Va. Little Rock, Ark. Los Angeles, Cal. Shreveport, La. Siou x Falls, S. Dak. Charlotte, N. C. Louisville, Ky. South Bend, Ind. Chattanooga, Tenn. Manchester, N. H. Spokane, Wash. Chicago, Ill. Cincinnati Ohio Memphis, Tenn. Meridian, Miss. Springfield, Mass. Springfield, Mo. Cleveland, bhio Miami, Fla. St. Louis, Mo. Columbia, S. C. Milwaukee, Wis. Syracuse, N. Y. Columbus, Ohio Minneapolis, Minn. Tampa, Fla. Dallas, Te x as Denver, Colo. Mobile, Ala. Montgomery, Ala. Toledo, Ohio Tulsa, Oklahoma Des Moines, Iowa Nashville, Tenn. Utica, N. Y. Detroit, Mich. New Orleans, La. Vicksburg, Miss. El Paso, Te x as New York, N. Y. Washington, D. C. Evansville, Ind. Fargo, N. Dak. Norfolk, Va. Oklahoma City, Okla. Wheeling, W. Va. Wichita Kan. Ft. Wayne, Ind. Omaha, Nebr. Wilson, N. C. Gastonia, N. C. Philadelphia, Pa. Winston-Salem, N. C. Grand Rapids, Mich. Great Falls, Mont. Phoeni x, Ariz. Pittsburgh, Pa. Worcester, Mass. Youngstown, Ohio IN CANADA Barrie, Ontario Belleville, Ont. Midland, Ont. Montreal, Que. Shelburne, Ont. Simcoe, Ont. Chatham, Ont. Orillia, Ont. St. Catharines, Ont. Cobalt, Ont. Oshawa, Ont. St. John, N. B. Edmonton, Alberta Owen Sound, Ont. St. Thomas, Ont. Fort William, Ont. Galt, Ont. Peterborough, Ont. Petrolia, Ont. Stratford, Ont. Toronto, Ont. Guelph, Ont. Regina, Sask. Vancouver, B. C. Halifa x, Nova Scotia Sarnia, Ont. Welland, Ont. Kingston, Ont. Saskatoon, Sask. Windsor, Ont. Kitchener, Ont. London, Ont. Sault Ste. Marie, Ont. Winnipeg, Manitoba INSTRUCTIONS FOR ORDERING PARTS Order parts through the nearest Distributor or Dealer. Always give PART NUMBER and NAME of each part ordered. 3 Mail and Parcel Post orders should be accompanied by an amount sufficient to cover POSTAGE. Specify how shipments are to be made. 5 Oders for parts should be written separately from correspondence pertaining to other matters. TELEGRAPH CODE To save expense, to expedite ordering and for your convenience, we list below a brief General Code covering miscellaneous instructions, questions and answers relative to the shipment of parts: Sulte x Ship to me (us) by express. Sulwire When and how did you ship parts - Sulkfine Ship by e x press to called for in my (our) telegram of Sulkate Ship to me (us) by freight. Sultwich When and how will you ship part Sulmost Ship to me (us) by parcel post. called for in my (our) telegram of Sulteen When and how will you ship parts

6 Hudson and Essex Coach Parts [5]

7 [] Hudson and Essex Coach Parts

8 HUDSON COACH BODY PARTS LIST 7 HUDSON COACH (For cars numbered 73 to BODY CO CO BO 30 BO 3 CO 7550 BO 75 BO 793 BO 79 BO 700 BO 37 BO 599 BZ 7 BO 7570 CO 7550 BT 395 BZ BO 535 BO 7537 GO 0 BO 7537 BO 90 BO BO 005 BZ 3 BO GO 0 BO 05 BO 790 GO 009 GO 0 GO 0 BO 77 BZ CO 755 BO 7 BO 700 BM 9 BZ BO 757 BO CO 750 BO BO 70 BO 0 CO 753 BO 70 BO 79 BO 750 CO 7537 BO 7537 BO 53 BO 753 BO 5 BO 759 BM Body complete L. H. D Body complete R. H. D Bolt and nut (7/"- x 3-/" carriage) Bolt and nut (7/"- x 5-/" carriage) COWL AND DASH ASSEMBLY Filler felt cowl to front pillar Curve clip cowl attaching "U" clip cowl attaching Screw (/"-0 x " round head) Shim body Lacing dash bonnet Rivet dash bonnet lacing Cowl quarter trim panel Dash assembly Bolt (5/"- x 5/" hex head) Nut ( &"- x /" hex ) Support dash bonnet hinge COWL VENTILATOR VENTILATOR COVER ASSEMBLY specify color; Hinge ventilator cover Bracket hinge to cowl Clevis pin (-3/" x 3/3") Spring ventilator Operating rod assembly Knob operating rod Set screw knob to rod Bracket rod to instrument board Screw (No. -3 x /") Nut (No. -3 x /") Washer operating rod Ball operating rod Spring knob tension Nut operating rod Screw operating rod nut FRONT PILLAR AND WINDSHIELD PANELS FRONT PILLAR ASSEMBLY Clinch not (/"-0 x 5/") Rivet (3/" x 3/" truss head) Bolt (5/"- x 3/" hex head) Nut (5/"- x 5/" hex.) Cover plate lock pillar Screw (No. x " sheet metal) Finish panel over windshield trimmed Clinch nut (No. -3 x 5/") Screw (No. -3 x 5/" oval head) Finish washer (No. countersunk) Finish panel under windshield (specify color) Screw (No. -3 x 3/" oval head) Nut (No. -3 x 3/" square) Filler finish panel Instrument panel (specify color) Plate instrument panel Step bolt (/"-0 x 3/") Bracket instrument panel plate Screw (/"-0 x 7/" round head) "U" bolt instrument panel bracket Nut (3/"- x 3/" hex ) FRONT SECTION COWL AND DASH INSTRUMENT PANEL

9 HUDSON COACH BODY PARTS LIST INSTRUMENT PANEL Continued BO 7539 BO 53 BO 5 BO 73 BO 5 BZ BZ 5 BO 53 BZ 0 Bracket instrument panel end Step bolt (5/- x 3/") Screw (/-0 x 7/" round head) Bracket instrument panel center Screw ("-0 x 7/" round head) Bracket steering gear cowl Bolt (7/"-0 x 3-/" hex head) Step bolt (5/"- x 3/") Nut (7/"-0 x 3/" hex ) I WINDSHIELD CO BO 7539 BO 7 BO 79 BO 700 BO 757 BO 7505 BO 750 BO 755 BO 5 BO 753 BO 7530 BO 7575 BO BO 7 BO 9 BO 757 BO 7570 BO 7505 BO CO 7509 BO 75 BO 753 BO BO 7003 CO 7555 BO BO 0 CO CO 7555 CO CO 7505 BO BO 7 BO BO 7557 BO 7535 BO 75 BO 5 BO 755 BO 7553 BO 7530 BO 753 BO 757 BO BO WINDSHIELD ASSEMBLY (less glass) Glass windshield not supplied; see note, page 3) Hinge windshield body half Screw (No. -3 x 5/" round head) Nut (No. -3 x 3/" square) Plug windshield frame Glass clip Screw glass clip Nut glass clip screw Bracket swing armbody Screw (No. -3 x 3/3" special) Bracket swing arm frame Swing arm Screw swing arm pivot Nut swing arm pivot screw Washer swing arm pivot screw Wing screw swing arm Rubber bumper Post rubber bumper Screw bumper post Weatherstrip windshield bottom Weatherstrip windshield side VISOR ASSEMBLY Bracket visor R. H Bracket visor L. H Screw ("-0 x -/" special) Rivet ( 9/" x 7/" special tubular) WINDSHIELD VISOR (For cars numbered from 73 to 73793) (For cars numbered from to 750,000) VISOR ASSEMBLY Screw (/"-0 x /" special) Finish washer (No. countersunk) DOOR ASSEMBLY R. H. (trimmed) DOOR ASSEMBLY L. H. (trimmed) DOOR ASSEMBLY R. H. (skeleton) DOOR ASSEMBLY L. H. (skeleton) Clinch nut (No. -3 x ") Clinch nut (/"-0 x 5/" special) Door upholstered panel R. H Door upholstered panel L. H Check strap door Loop door check strap Screw (/"-0 x 7/" round head) Door hinge body half Door hinge door half Shield door hinge R. H Shield door hinge L. H Hinge rod Screw (/"-0 x -/') Shakeproof lockwasher (/") CENTER SECTION DOORS (Specify color of paint and upholstering) DOOR HINGES 7 7 I

10 HUDSON COACH BODY PARTS LIST 9 CO 7503 BO 750 BO 5 BO 53 BO 0 BO 75 BO 7537 BO BO 753 BO 759 BO 757 BO 797 BO 750 BO 70 BO 7503 BO 70 BO 755 BO 75 BO 5 BO 75 BO 7 BO 75 BO 75 BO 75 BO 5 BO 75 BO 7555 BO 59 BO 0 BO 7007 BO 755 BO 755 BO 755 BO BO 755 BO 750 BO BO 7509 BO BO 75 BO 700 BO 750 BO 750 BO BO 7553 BO 75 BO 75 BO 757 BO 7530 BO 759 BO BO 755 BO 757 BO 7507 BO 70 BO 75 BO 5 BO 50 BO 753 BO 59 BO 79 BO 75 DOOR LOCKS DOOR LOCK ASSEMBLY R. H DOOR LOCK ASSEMBLY L. H Screw (/"-0 x /" oval head) Screw (/"-0 x /" round head) Nut (/-0 x / square) Shakeproof lockwasher (/" countersunk) Spring lock inside cam dog Spring lock inside cam Coil spring lock inside Door safety lock assembly Key door safety lock Set screw door safety lock Door lock outside handle Screw (No. -3 x 5/" oval head) Door lock inside handle Screw (No. -3 x 5/" oval head) Trim retainer inside handle Door dovetail case female Screw (/"-0 x /" oval head) Shakeproof lockwasher (/" countersunk) Rubber bumper dovetail Retainer dovetail rubber bumper Door dovetail male Plate dovetail Screw dovetail Shakeproof lockwasher Striker plate door lock Screw (No. -3 x /" round head) Screw (No. -3 x 7/" round head) Shakeproof lockwasher (3/ ) Retainer door lock striker plate Rubber bumper door Retainer door rubber bumper Screw ( "-0 x /" oval head) DOOR DOVETAILS AND BUMPERS DOOR GLASS AND CHANNELS Door glass (not supplied; see note, page 3) Rubber bumper door glass Door glass upper channel see weatherstrips Door glass side channel assembly Retainer assembly R. F. and L. R. channel Retainer assembly L. F. and R. R. channel Clinch nut (No. -3 x 5/") Clip channel retainer Rivet i No. 9 x " crown head) Door glass bottom channel R. H. (cars numbered from 73 to 733) Dour glass bottom channel L. H. (cars numbered from 73 to 733) Door glass bottom channel R. H. (cars numbered 733 to ) Door glass bottom channel L. H. (cars numbered 733 to ) Cork shim glass to channel thin Cork shim glass to channel medium... Cork shim glass to channel thick DOOR WEATHERSTRIPS AND TRIM RETAINERS Door glass weatherstrip and retainer top Door glass weatherstrip and retainer bottom Screw (No. x /" sheet metal) Door bottom weatherstrip and trim retainer.. Trim retainer door bottom Weatherstrip door bottom Screw (No. -3 x 5/" oval head) DOOR WINDLACE WINDLACE AND RETAINER ASSEMBLY lock pillar Screw (No. -3 x 5/ " special head) Nut (No. -3 special) Windlace and retainer assembly hinge pillar Screw (No. -3 x 5/" round head) Nut (No. -3 x 3/ square) Windlace and retainer assembly over door I

11 HUDSON COACH BODY PARTS LIST Part. No. BO 7537 BO 59 BO 70 BO 0 BO 7553 BO 59 BO 7007 BO 7507 BO BO BO 79 BO 7507 BO BO 7500 BO 750 BO 777 BO 730 BO 733 BO BO 79 BO 753 BO 50 BO 77 BO 90 BO 9 BO 95 BO 93 BO 5 BO 9 BO BO 7505 BO 5 BO 75 BO 7595 BO 7339 BO 733 BO 733 BO 7337 BO 730 BO 733 BO 7533 BO 59 BO 79 BO 90 BO 9 BO 95 BO 93 BO 5 BO 9 BO CO 75 CO 75 BO BO 7 BO 700 CO CO BO 55 BO 59 BO BO 7 BO 700 BO 0 BO 79 Finish strip door top Screw (No. -3 x /" round head) Screw (No. -3 x 5/" oval head) Finish washer (No. countersunk) Finish strip door bottom Screw (No. -3 x /" round head) Shakeproof lockwasher (3/") DOOR WINDOW FINISH STRIPS DOOR WINDOW REGULATOR R. H DOOR WINDOW REGULATOR L. H Screw (No. -3 x 5/" flat head) Nut (No. -3 x 3/" square) Worm and gear case assembly R. H Worm and gear case assembly L. H Arm assembly regulator Arm assembly regulator Split nut regulator arm Roller regulator arm Pin regulator arm roller Screw (No. -3 x 5/" flat head) Nut (No. -3 x 3/" square) Rivet regulator arm pivot Spring regulator Clip regulator spring Handle regulator Screw regulator handle Washer regulator handle Anti-rattler washer regulator handle (rubber) Anti-rattler washer regulator handle (steel) Escutcheon plate regulator handle DOOR WINDOW REGULATOR (For cars numbered from 739 to 733) (For cars numbered from 733 to DOOR WINDOW REGULATOR ASSEMBLY R. H DOOR WINDOW REGULATOR ASSEMBLY L. H Screw ("-0 x /" oval head) Shakeproof lockwasher ("" countersunk) Spacer regulator Spring regulator Pinion regulator / Arm and sector assembly R. H. regulator Arm and sector assembly L. H. regulator Roller regulator arm Pin regulator arm roller Stop regulator arm Screw (No. -3 x /" round head) Nut (No. -3 x 3/" square) Handle regulator Screw regulator handle Washer regulator handle Anti-rattler washer regulator handle (rubber) Anti-rattler washer regulator handle (steel) Escutcheon plate regulator handle Spacer (This spacer and lower channels and 7553 are necessary to replace 7507 and regulators by and 7505 regulators) HINGE PILLAR ASSEMBLY R. H HINGE PILLAR ASSEMBLY L. H Clinch nut (No. -3 x 5/") Clinch nut (/"-0 x / Rivet (3/ x 3/"" truss head) Rear quarter pillar assembly R. H. Rear quarter pillar assembly L. H. Screw (/"-0 x -/" flat head) Screw (No. -3 x /" round head) Clinch nut (No. -3 x 5/" Rivet (3/" x 5/" truss head) Rivet (3/" x 3/" truss head) Nut (/"-0 x /" square) Nut (No. -3 x 3/" square) REAR SECTION HINGE AND QUARTER PILLARS 0

12 HUDSON COACH BODY PARTS LIST QUARTER GLASS AND CHANNELS 753 Quarter window glass (see note, page 3) Quarter glass channel top see weatherstrips BO 7507 BO 75 Quarter glass side channel and retainer assembly Channel quarter glass side BO 59 Screw (No. -3 x /" round head) BZ 799 Nut (No. -3 x /" he x.) BO 700 BO Rivet (No. 9 x /" crown head tubular) Quarter window channel assembly R. H BO 7553 Quarter window channel assembly L. H BO 75 Cork shim glass to bottom channel thin BO 75 Cork shim glass to bottom channel medium BO 757 Cork shim glass to bottom channel thick 7ETAINERS BO 7530 BO 759 BO BO 75 BO 70 BO 79 Quarter window weatherstrip and retainer top Quarter window weatherstrip and retainer bottom Screw (No. x /" sheet metal) Retainer quarter trim bottom Screw (No. -3 x 5/" oval head) Nut No. -3 x 3/" square) QUARTER WINDOW FRAME AND CURTAINS CO 755 QUARTER GLASS FRAME ASSEMBLY (finish moulding) BO 7 Screw (No. -3 x 5/" round heads BO 333 BO 53 Rivet (3/" x /" crown head tubular) Screw ("-0 x /" round head) BO 0 Nut ("-0 x /" square) BO 9 Rivet (No. 9 x 5/3" flat head tubular) BO 759 BO Quarter window curtain and roller assembly Screw (No. -3 x 3/") BO 759 Quarter window curtain card QUARTER WINDOW REGULATOR BO QUARTER WINDOW REGULATOR ASSEMBLY R. H. BO 7505 QUARTER WINDOW REGULATOR ASSEMBLY L. H. BO 5 Screw (/"-0 x /" oval head) BO 75 BO 7595 Shakeproof lockwasher (/" countersunk) Spacer regulator BO 7339 Spring regulator BO 733 Pinion regulator BO 733 Arm and sector assembly R. H BO 7337 BO 730 Arm and sector assembly L. H Roller regulator arm BO 733 Pin regulator arm roller BO 7533 Arm stop regulator BO 59 Screw (No. -3 x./" round head) BO 79 BO 90 Nut (No. -3 x 3/" square) Handle regulator BO 9 Screw regulator handle BO 95 Washer regulator handle BO 93 Anti-rattler washer handle (rubber) BO 5 BO 9 Anti-rattler washer handle (steel) Escutcheon plate handle OUTSIDE PANELS AND MOULDINGS (Specify color) CO 753 Quarter panel upper R. H. CO 75 Quarter panel upper L. H. BO CO 755 Screw (No. x /" sheet metal) Quarter panel lower and wheel house assembly R. H. CO 7557 Quarter panel lower and wheel house assembly L. H. BO Rivet (No. 9 x 3/" flat head tubular) BO Screw (No. x /"sheet metal) BO 5 BO 0 Screw (/"-0 x -/" oval head) Nut (/""-0 x /" square) CO 75 Back panel upper CO 7533 Back panel lower BO 53 Screw (/"-0 x /" round head) BO 0 BO 7005 Nut (/"-0 x /" square) Rivet (No. 9 x 5/" flat head tubular) BO 9 Nail (/" x 3/" countersunk head) BO 7533 Cage fender bolt nut BO 750 Cage fender bolt nut BM BO 3 Nut fender bolt Nut fender bolt

13 HUDSON COACH BODY PARTS LIST BO 7500 BO BO 7535 BO 750 CO 7503 CO 750 BO 7505 BO 750 BO BO BO 7 BO 7 BO 7503 CO 7503 BO 9 BO 7593 BO 759 CO 7559 CO 7555 CO CO 7555 BO 7550 BO 755 BO 755 BO 7553 BO 755 B x BM 5550 BO 3 BO 75 BO 753 BO 75 BO 9 BO 755 BO 7557 BO BO 7503 BO BO 7550 BO 755 BO 753 CO BO 757 BO 750 BO 753 BO 707 BO 09 BO 3 BO 3 BO 0 CO 7557 BO 7559 CO 7 BO 033 BO BO 70 Moulding side Moulding R. H. rear vertical Moulding L. H. rear vertical Moulding rear horizontal OUTSIDE PANELS AND MOULDINGS Continued Rear quarter lower upholstered panel R. H Rear quarter lower upholstered panel L. H. Rear corner upholstered panel R. H Rear corner upholstered panel L. H. Back upholstered panel upper Back upholstered panel lower REAR UPHOLSTERED PANELS (Specify color) REAR WINDOW Rear window glass (not supplied; see note, page 3) Channel rear window long Channel rear window short Rear window moulding assembly Rear window frame assembly Nail (/ x " countersunk head) Rear window curtain and roller assembly Cord rear window curtain Roof rail front Roof rail rear Roof rail side R. H. Roof rail side L. H.. Bow No. Bow No. Bow No. 3 Bow No. Bow No. 5 Bolt (5/"- x -3/" hex. head) Bolt (5/"- x -3/" hex. head) Nut (5/"- x /" square) Binding roof rail front Binding roof rail rear Drip moulding Nail (/" x 3/" countersunk head) Finish strip drip moulding Top deck material Crosspiece over door Crosspiece over door Bracket roof rear corner Plate roof rear corner Dome light assembly Door assembly dome lamp FOLDING SEAT ASSEMBLY (specify color) Support folding seat front Nut cage folding seat support Floor bracket folding seat front Adjusting bolt assembly Rubber cap adjusting bolt Nut adjusting bolt Washer adjusting bolt Adjusting bolt Folding seat back (specify color) Covering folding seat back (specify color) Back and support assembly (not trimmed) Support folding seat back Adjusting screw folding seat back Bottom trim board TOP SECTION ROOF FLOOR SECTION SEATS AND CUSHIONS 0 I I 5

14 HUDSON COACH BODY PARTS LIST 3 SEATS AND CUSHIONS Continued CO 7553 CO 7553 BO 759 BO 757 BO BO 7553 BO 7 BO BO 79 A 75 CO 7559 BZ 55 BO 7 CO CO 75 CO 753 BO 55 BO 0 BO 75 BO 0 BO 55 BO 753 BO 3 BO 700 BO 757 BO 7539 BO 75 BO 33 BO 7 BO 35 BO 7539 BO BO 359 BO 733 BO 73 BO Cushion rear seat (specify color) Rear seat back complete (specify color) Dowel rear seat cushion Hinge rear seat back TOE AND FLOOR BOARDS TOE BOARD RISER ASSEMBLY R. H TOE BOARD RISER ASSEMBLY L. H Screw (No. -3 x 5/" round head) Clinch nut (No. -3 x 5/") Nut (No. -3 x 5/" square) Toe plate and ledge assembly Toe plate and accelerator pedal bracket assembly Shim toe plate Screw (No. -3 x 5/" round head) Floor board assembly front Center floor board R. H Center floor board L. H. Bolt (/"-0 x -/" flat head) Nut (/"-0 x /" square) Rear floor board Nut (3"-0 x ' square) Bolt (/"-0 x -/" flat head) Rear floor carpet (specify color) Glove fastener button and drive screw Carpet fastener Rear seat heel board carpet Front floor rubber mat L. H. D Front floor rubber mat R. H. D. Fastener socket Fastener socket plate Fastener post Felt pad L. H. D. Felt pad R. H. D. Clincher button Scuff plate R. H. Scuff plate L. H. Rivet (No. 9 x /" flat head tubular) CARPETS, MATS AND PADS SCUFF PLATE

15 ESSEX COACH BODY PARTS LIST ESSEX COACH For cars numbered 7 to , BODY CO CO 7559 BO 30 BO 700 CO 753 BO BO 793 BO 79 BO 700 BO 7590 BO BO 95 BO 7570 CO 753 BT 395 BZ BO 0 GZ 33 BZ 9 BO BO 750 BO 7537 BO 753 BO 90 BO 0 BO 7539 BO 7 BO 79 BO 07 BO 09 CO BO 7 BO 700 BM 9 BZ BO 757 BO CO 7507 CO 7573 BO BO 70 BO 0 CO 755 BO 700 BO 79 BO 750 CO 7553 BO 757 BO 53 BO 75 BO 700 BO 759 BM BO 755 BO 53 Body complete L. H. D Body complete R. H. D. Bolt and nut (7/ - x 3-/" carriage) Bolt and not (7/"- x -/" carriage) COWL AND DASH ASSEMBLY Filler rubber cowl to front pillar Curve clip cowl attaching "U" clip cowl attaching Screw (/" -0 x " round head) Shim body front end Lacing bonnet ledge Rivet (9/" x /" countersunk split) Cowl quarter trim panel Dash assembly Bolt (3/"- x 5/" hex. head) Nut ( 5/"'- x 5/" hex.) Support dash bonnet hinge Rubber ferrule (7/") Rubber ferrule (/") VENTILATOR COVER ASSEMBLY Handle ventilator cover Hinge ventilator cover Bracket ventilator cover hinge Clevis pin (3/" x 3/3") Anti-rattler ventilator handle Quadrant ventilator Screw (No. -3 x h' round head) Nut (No. -3 x A" square) Spring ventilator handle Retainer ventilator handle FRONT PILLAR ASSEMBLY Clinch nut (/"-0 x 5/ ) Rivet (3/" x 3/" truss head) Bolt (5/"- x 3/" hex. head) Nut ( 5/"- x 5/" hex.) Cover plate lock pillar Screw (No. x 3/" sheet metal) Finish panel over windshield trimmed Finish panel over windshield less trim Clinch nut (No. -3 x 5/"). Screw (No. -3 x 5/" oval head) Finish washer (No. countersunk) Finish panel under windshield Screw (No. -3 x 7/" oval head) Nut (No. -3 x 3/" square) Filler finish panel Instrument panel Plate instrument panel Bolt (5/"- x 3/" step) Bracket instrument panel plate Screw (/"-0 x " round head) "U" bolt instrument panel bracket Nut (3/"- x 3/" hex.) Bracket instrument panel end Bolt ( 5/"- x 3/" step) FRONT SECTION COWL AND DASH COWL VENTILATOR (Specify color) FRONT PILLAR AND WINDSHIELD PANELS INSTRUMENT PANEL (Specify color, II

16 ESSEX COACH BODY PARTS LIST 5 INSTRUMENT PANEL Continued BO 700 BZ 75 BO 53 BO 93 BO 7007 Screw (/"-0 x " round head) Bracket steering gear cowl Bolt (5/"- x 3/" step) Bolt (3/"- x ' hex. head) Nut (3/"- x 3/" parkerized) WINDSHIELD CO BO 7539 BO 7 BO 79 BO 700 BO 757 BO 7505 BO 750 BO 755 BO 5 BO 753 BO 7530 BO 7575 BO BO 7 BO 9 BO 7570 BO 757 BO 7505 BO 7570 BO 7575 CO 7509 BO 75 BO 753 BO BO 7003 BO 0 CO 7555 BO BO 0 CO CO 7555 CO CO 7509 BO BO 7 BO 750 BO 75 BO 7535 BO 75 BO 5 BO 753 BO 753 BO 757 BO BO WINDSHIELD ASSEMBLY (less glass) Glass-windshield not supplied; see note, page 3) Hinge-windshield body half Screw (No. -3 x 5/" round head) Nut (No. -3 x 3/" square) Plug-windshield frame Glass clip Screw glass clip Nut-glass clip screw Bracket swing arm body Screw (No. -3 x 3/3" special) Bracket-swing arm frame Swing arm Pivot screw swing arm Nut swing arm pivot screw Washer-swing arm pivot screw Wing screw-swing arm Rubber bumper Post-rubber bumper Screw bumper post Weatherstrip windshield bottom Weatherstrip-windshield side VISOR ASSEMBLY Bracket-visor-R. H. Bracket visor L. H. Screw ("-0 x /" special) Rivet (9/" x 7/" special tubular) Finish washer (No. countersunk) WINDSHIELD VISOR (For cars numbered from 7 to 395) (For cars numbered 395 to ) VISOR ASSEMBLY Screw (/"-0 x '" special) Finish washer (No. countersunk) DOOR ASSEMBLY R. H. trimmed DOOR ASSEMBLY-L. H. trimmed DOOR ASSEMBLY-R. H. skeleton DOOR ASSEMBLY-L. H. skeleton Clinch nut (No. -3 x 5/") Clinch nut (/"-0 x /" special) Door upholstered panel R. H. Door upholstered panel L. H Check strap door Loop door check strap Screw (/ "-0 x 7/" round head) Door hinge-body half Door hinge door half Hinge rod Screw (/"-0 x /" special) Shakeproof lockwasher special) CENTER SECTION DOORS (Specify color of paint and upholstering) DOOR HINGES 7 7 I

17 ESSEX COACH BODY PARTS LIST DOOR LOCKS BO 7503 BO 750 BO 5 BO 53 BO 0 BO 75 BO 7537 BO BO 753 BO 759 BO 757 BO 797 BO 750 BO 70 BO 7503 BO 70 BO 755 BO 75 BO 7 BO 75 BO 5 BO 75 BO 75 BO 5 BO 75 BO 75 BO 7555 BO 59 BO 0 BS) 7007 BO 755 BO 755 BO 755 BC BO 755 BO 750 BO BO 7509 BO BO 75 BO 700 BO 750 BO 7503 BO BO 7553 BO 755 BO 75 BO 757 BO 7530 BO 759 BO BO 755 BO 757 BO 70 BO 75 BO 5 BO 50 BO 753 BO 59 BO 79 BO 75 DOOR LOCK ASSEMBLY R. H DOOR LOCK ASSEMBLY L. H Screw (/"-0 x /" oval head) Screw (/-0 x /" round head) Nut (/"-0 x /" square) Shakeproof lockwasher (/" countersunk) Spring lock inside cam dog Spring-lock inside cam Coil spring lock inside Door safety lock assembly Key door safety lock Set screw-door safety lock Handle door lock outside Screw (No. -3 x 5/" oval head) Handle door lock inside Screw (No. -3 x 5/" oval head) Trim retainer inside handle Door dovetail case female Rubber bumper door dovetail Retainer dovetail rubber bumper Screw (/"-0 x /" oval head) Shakeproof lockwasher (/" countersunk) Door dovetail male Screw (/ -0 x /" oval head) Shakeproof lockwasher (, countersunk) Plate door male dovetail Striker plate door lock Screw (No. -3 x 3/" round head) Screw (No. -3 x 3/" round head) Shakeproof lockwasher (3/) Retainer door lock striker plate Rubber bumper door Retainer door rubber bumper Screw (/"-0 x /" oval head) DOOR DOVETAIL AND BUMPERS DOOR GLASS AND CHANNELS Door glass (not supplied; see note, page 3) Rubber bumper-door glass Door glass upper channel see weatherstrips Door glass side channel assembly Retainer assembly-r. F. and L. R. channel Retainer assembly L. F. and R. R. channel Clinch nut (No. -3 x 5/") Clip-channel retainer Rivet (No. 9 x /" crown head) Door glass bottom channel R. H. (for cars numbered from 7 to 735). Door glass bottom channel L. H. (for cars numbered from 7 to 7535) Door glass bottom channel R. H. (for cars number ed from 7(35 to ) Door glass bottom channel L. H. (for cars numbered from 7535 to ). Cork shim glass to channel thin Cork shim glass to channel-medium Cork shim glass to channel-thick DOOR WEATHERSTRIPS AND TRIM RETAINERS DOOR GLASS WEATHERSTRIP AND RETAINER ASSEMBLY top Door glass weatherstrip and retainer assembly bottom Screw (No. x /" sheet metal) Door weatherstrip and retainer assembly-bottom Retainer-weatherstrip and trim door bottom Screw (No. -3 x 5/" oval head) DOOR WINDLACE WINDLACE AND RETAINER ASSEMBLY lock pillar Screw (No. -3 x 3/3" special head) Nut (No. -3 special) Windlace and retainer assembly hinge pillar Screw (No. -3 x /" round head) Nut (No. -3 x 3/" square) Windlace and retainer assembly over door

18 ESSEX COACH BODY PARTS LIST 7 DOOR WINDOW FINISH STRIPS BO 7537 BO 59 BO 70 BO 0 BO 7553 BO 59 BO 7007 Finish strip door top Screw (No. 3-3 x /" round head) Screw (No. -3 x 3/" oval head) Finish washer (No. countersunk) Finish strip-door bottom Screw (No. -3 x /" round head) Shakeproof lockwasher (3/") DOOR WINDOW REGULATOR (For cars numbered from 7 to 735) BO 7507 BO BO BO 79 BO 7507 BO BO 7500 BO 750 BO 50 BO 77 BO 777 BO 730 BO 733 BO BO 79 BO 753 BO 90 BO 9 BO 95 BO 93 BO 5 BO 9 BO BO 7505 BO 5 BO 75 BO 7595 BO 7339 BO 733 BO 7C335 BO 7337 BO 730 BO 7E33 BO 7533 BO 59 BO 79 BO 90 BO 9 BO 95 BO 93 BO 5 BO 9 BO CO 750 CO 7505 BO BO 7 BO 700 CO CO 7505 BO 55 BO 59 BO BO 7 BO 700 BO 0 BO 79 DOOR WINDOW REGULATOR ASSEMBLY R. H DOOR WINDOW REGULATOR ASSEMBLY L. H Screw (No. -3 x 5/ flat head) Nut (No. -3 x 3" square) Worm and gear case assembly-r. H. Worm and gear case assembly L. H Arm assembly-regulator I Arm assembly regulator Spring regulator Clip-regulator spring Split nut regulator arm Roller regulator arm Pin-regulator arm roller Screw (No. -3 x 5/" flat head) Nut (No. -3 x 3/" square) Rivet regulator arm pivot Handle-regulator Screw-regulator handle Washer-regulator handle screw Anti-rattler washer handle (rubber) Anti-rattler washer-handle (steel) Escutcheon plate regulator handle (For cars numbered 7535 to 5000) DOOR WINDOW REGULATOR ASSEMBLY R. H DOOR WINDOW REGULATOR ASSEMBLY-L. H Screw ("-0 x /" oval head) Shakeproof lockwasher (/" countersunk) Spacer-regulator Spring regulator Pinion-regulator Arm and sector assembly-r. H. regulator Arm and sector assembly L. H. regulator Roller regulator arm Pin regulator arm roller Arm stop regulator Screw (No. -3 x /" round head) Nut (No. -3 x 3/" square). Handle regulator Screw-regulator handle Washer regulator handle Anti-rattler washer handle (rubber) Anti-rattler washer-handle (steel) Escutcheon plate-handle Spacer (This spacer and lower channels and 7553 are necessary in replacing 7507 and regulators by and 7505 regulators) REAR SECTION HINGE AND QUARTER PILLARS HINGE PILLAR ASSEMBLY R. H HINGE PILLAR ASSEMBLY L. H Clinch nut (No. -3 x 5/ ) Clinch nut (/"-0 x 5/") 0 Rivet (3/ x 3/") truss head) Rear quarter pillar assembly R. H Rear quarter pillar assembly L. H Screw (/"-0 x -/" flat head) Screw (No. -3 x 5/" round head) Clinch nut (No. -3 x 5/") Rivet (3/" x 5/ truss head) Rivet (3/ x 3/ truss head) Nut (/"-0 x /" square) Nut (No. -3 x 3/" square)

19 ESSEX COACH BODY PARTS LIST 753 BO 7507 BO 75 BO 59 BZ 799 BO 700 BO BO 7553 BO 75 BO 75 BO 757 BO 7530 BO 759 BO BO 75 BO 70 BO 79 CO 755 BO 7 BO 333 BO 53 BO 0 BO 9 BO BO 7505 BO 5 BO 75 BO 7595 BO 7339 BO 733 BO 733 BO 7337 BO 730 BO 733 BO 7533 BO 59 BO 79 BO 90 BO 9 BO 95 BO 93 BO 5 BO 9 CO 7535 CO 753 BO CO 750 CO 750 BO BO BO 5 BO 0 CO 75 CO 75 BO 53 BO 0 BO 7005 BO 9 BO 7533 BO 750 BM BO 3 BO 7500 BO 750 BO 750 QUARTER GLASS AND CHANNELS Quarter window glass (see note, page 3) Quarter glass channel top-see weatherstrips Quarter glass side channel and retainer assembly Channel-quarter glass side Screw (No. -3 x /" round head) Nut (No. -3 x /" hex.) Rivet (No. 9 x /" crown head tubular) Quarter window channel assembly R. H. bottom Quarter window channel assembly L. H. bottom Cork shim-glass to bottom channel thin Cork shim-glass to bottom channel-medium Cork shim glass to bottom channel thick QUARTER WINDOW WEATHERSTRIPS AND TRIM RETAINERS Quarter window weatherstrip and retainer-top Quarter window weatherstrip and retainer bottom Screw (No. x /" sheet metal) Trim retainer rear quarter bottom Screw (No. -3 x 5/" oval head) Nut No. -3 x 3/" square) QUARTER WINDOW FRAME QUARTER GLASS FRAME ASSEMBLY (finish moulding) Screw (No. -3 x 5/" round head) Rivet (3/ x /" crown head tubular) Screw (/"-0 x /" round head) Nut (3"-0 x /" square) Rivet (No. 9 x 5/3") flat head tubular) QUARTER WINDOW REGULATOR QUARTER WINDOW REGULATOR ASSEMBLY R. H QUARTER WINDOW REGULATOR ASSEMBLY L. H Screw (/"-0 x /" oval head) Shakeproof lockwasher (/" countersunk) Spacer regulator Spring-regulator Pinion-regulator Arm and sector assembly R. H Arm and sector assembly L. H Roller-regulator arm Pin-regulator arm roller Arm stop regulator Screw (No. -3 x /" round head) Nut (No. -3 x 3/" square) Handle-regulator Screw regulator handle Washer regulator handle Anti-rattler washer-handle (rubber) Anti-rattler washer-handle (steel) Escutcheon plate-handle OUTSIDE PANELS AND MOULDINGS (Specify color) Quarter panel upper R. H Quarter panel upper L. H. Screw (No. x /" sheet metal) Quarter panel lower-and wheel house assembly R. H Quarter panel-lower-and wheel house assembly L. H. Rivet (No. 9 x 3/" flat head tubular) Screw (No. x 3/" sheet metal) Screw (/"-0 x /" oval head) Nut (/"-0 x /" square) Back panel upper Back panel-lower Screw (/"-0 x /" round head) Nut ("-0 x /" square) Rivet (No. 9 x 3/" flat head tubular) Nail (/" x 3/" countersunk head) Cage fender bolt nut Cage fender bolt nut Nut-fender panel bolt Nut fender panel bolt Moulding side Moulding-rear vertical Moulding-rear horizontal

20 ESSEX COACH BODY PARTS LIST 9 REAR UPHOLSTERED PANELS (Specify color) CO 75 CO 753 BO 7507 BO 7507 BO BO BO 7 BO 7 BO 7503 CO 7503 BO 9 CO 7559 CO 7555 CO CO 7555 BO 7550 BO 755 BO 755 BO 7553 BO 755 B x BM 5550 BO 3 BO 75 BO 753 BO 75 BO 9 BO 755 BO 7557 BO 759 BO 7550 BO CO 75 BO 757 BO 750 BO 753 BO 707 BO 09 BO 3 BO 3 BO 0 CO 755 BO 755 CO 7 BO 033 BO BO 70 BO 757 BO 759 BO 75 BO 757 Rear quarter lower upholstered panel R. H Rear quarter lower upholstered panel L. H Rear corner upholstered panel-r. H Rear corner upholstered panel L. H Back upholstered panel-upper Back upholstered panel lower REAR WINDOW Rear window glass (not supplied; see note, page 3) Channel rear window long Channel rear window short Rear window moulding assembly Rear window frame assembly Nail (/" x 3/" countersunk head) Roof rail front Roof rail rear Roof rail side-r. H Roof rail side L. H Bow No. Bow No. Bow No. 3 Bow No. Bow No. 5 Bolt (5/"- x -3/'' hex. head) Bolt (5/"- x -3/" hex. head) Nut (5/"- x /" square) Binding roof rail-front Binding-roof rail rear Drip moulding Nail (/" x 3/" countersunk head) Finish strip drip moulding Top deck material Crosspiece-over door Crosspiece-over door Bracket roof rear corner FOLDING SEAT ASSEMBLY (specify color) Support folding seat front Nut cage folding seat support Floor bracket-folding seat front Adjusting bolt assembly-folding seat rear Rubber cap-adjusting bolt Nut adjusting bolt Washer adjusting bolt Adjusting bolt Folding seat back (specify color) Covering-folding seat back (specify color) Back and support assembly (not trimmed) Support folding seat back Adjusting screw folding seat back Trim board folding seat bottom Cushion rear seat (specify color) Dowel rear seat Cushion-rear seat back (specify color) Hinge rear seat back TOP SECTION ROOF FLOOR SECTION SEATS AND CUSHIONS 0 5

21 0 ESSEX COACH BODY PARTS LIST TOE AND FLOOR BOARDS BO 753 BO 7535 BO 7 BO BO 79 CO 759 BO 55 BZ 55 BO 7 A 09 BO 7 BO 75 BO 55 BO 75 BO 753 BO 55 BO 0 BO 75 BO 55 BO 0 BO 7597 BO BO 700 BO 753 BO 3 BO 700 BO 757 BO 757 BO 757 BO 33 BO 7 BO 35 BO 7573 BO 757 BO 359 TOE BOARD RISER ASSEMBLY R. H TOE BOARD RISER ASSEMBLY L. H Screw (No. -3 x 3/" round head) Clinch nut (No. -3 x 5/") Nut (No. -3 x 3/" square) Toe plate and accelerator rod assembly Toe plate assembly Shim-toe plate Screw (No. -3 x 5/" round head) Front floor board steel Screw (No. -3 x 5/" round head) Front floor board wood Bolt (/"-0 x -/" flat head) Center floor board-r. H Center floor board L. H Bolt (/"-0 x -/" flat head) Nut (/"-0 x /" square) Rear floor board Bolt (/"-0 x -/" flat head) Nut (/"-0 x /" square) Scuff plate R. H Scuff plate L. H Screw (No. -3 x / oval head) Rear floor carpet (specify color) Glove fastener button and drive screw Carpet fastener Rear seat heel board carpet Front floor rubber mat L. H. D Front floor rubber mat R. H. D. Fastener socket Fastener socket plate Fastener post Floor and dash felt pad L. H. D Floor and dash felt pad R. H. D. Clincher button CARPETS, MATS AND PADS

22 ESSEX COACH BODY PARTS LIST ESSEX SEDAN (For cars numbered 755 to ) BODY COMPLETE CO CO 7577 BO 30 BO 700 Body complete L. H. D. Body complete R. H. D. Bolt and nut (7/"-x3/" carriage) Bolt and nut (7/"-x-/" carriage) Essex Sedan Parts CO 753 BO 793 BO 79 BO 7007 BO 0 BO 7590 BO BO 95 CO 753 BZ 395 BZ BO 0 COWL AND DASH ASSEMBLY Curve clip cowl attaching "U" clip cowl attaching Screw /"-0 x /" round head) Nut (/"-0 x /" square) Shim body front end Lacing bonnet ledge Rivet (9/" x /" countersunk split) Dash assembly Bolt (5/"- x 5/" hex. head) Nut (5/"- x 5/" hex.) Support dash bonnet hinge FRONT SECTION COWL AND DASH 9

23 ESSEX COACH BODY PARTS LIST BM 9 BZ GZ 33 BZ 9 Bolt ( (5/"- x 3/" hex. head) Nut ( (5/"- x 5/" hex.) Rubber ferrule (7/") Rubber ferrule (/'") COWL AND DASH Continued 5 BO BO 750 BO 7539 BO 7 BO 79 BO 07 BO 09 BO 7539 BO 753 BO 90 CO BO 700 BM 9 BZ BO 757 BO CO 759 CO 7573 BO BO 70 BO 0 CO 755 BO 700 BO 79 CO 7553 BO 757 BO 53 BO 75 BO 700 BO 759 BM BO 755 BO 53 BO 700 BZ 75 BO 53 BO 93 BO 7007 CO BO 7539 BO 7570 BO 757 BO 757 BO 7505 BO 750 BO 755 BO 5 BO 753 BO 7530 BO 7575 BO BO 9 BO 7 BO 7570 BO 7575 COWL VENTILATOR COVER ASSEMBLY Handle ventilator handle Quadrant ventilator Screw (No. -3 x 5/" round head) Nut (No. -3 x 3/" square) Spring ventilator handle Retainer ventilator handle spring Hinge ventilator cover Bracket ventilator cover hinge Clevis pin (3/" x 3/3") COWL VENTILATOR (Specify color) FRONT PILLAR AND WINDSHIELD PANELS FRONT PILLAR ASSEMBLY Clinch nut (/-0 x 5/") Rivet (3/" x 3/" truss head) Bolt (5/"- x 3/" hex. head) Nut (5/"- x 5/" hex.) Finish plate lock pillar Screw (No. x /" flat head) Finish panel over windshield (trimmed) Finish panel over windshield (less trim) Clinch nut (No. -3 x 5/") Screw (No. -3 x 3/ oval head) Finish washer (No. countersunk) Finish panel under windshield (specify color) Screw (No. -3 x 7/" oval head) Nut (No. -3 x 3/" square) Instrument panel Plate instrument panel Bolt (5/"- x 3/" step) Bracket instrument panel plate Screw ("-0 x " round head) "U" bolt instrument panel bracket Nut (3/"- x 3/" hex.) Bracket instrument panel end Bolt (5/"- x 3/" step) Screw (/"-0 x " round head) Cowl bracket steering gear Bolt (5/"- x 3/" step) Bolt (3/"- x -/" hex. head) Nut (3/"- x 3/" parkerized) INSTRUMENT PANEL WINDSHIELD WINDSHIELD ASSEMBLY (less glass) Glass windshield (not supplied; see note, page 3) Hinge body half Rubber bumper Rubber bumper post Glass clip Screw glass clip and bumper post Nut glass clip screw Body bracket swing arm Screw (No. -3 x 3/3" special) Frame bracket swing arm Swing arm Pivot screw swing arm Nut swing arm pivot screw Wing screw swing arm Washer swing arm wing screw Weatherstrip frame lower Weatherstrip frame side I 3 3

24 ESSEX COACH BODY PARTS LIST 3 WINDSHIELD VISOR (For cars numbered from 755 to 395) CO 7509 BO 75 BO 753 BO BO BO 7003 CO 7555 BO BO 0 BO CO 73 CO 733 BO 753 CO 7599 CO CO 7 CO 7 CO 73 CO 7 CO 75 CO 7 CO 77 CO 7 BO BO 7 CO 759 CO 7595 CO 7590 CO 759 BO 753 BO 753 BO 757 BO 750 BO 7579 BO 75 BO 757 BO 753 BO BO BO 7503 BO 7570 BO 750 BO 53 BO 5 BO 0 BO 75 BO BO 7537 BO 753 BO 759 BO 757 BO 77 BO 750 BO 70 BO 7503 BO 70 BO 755 WINDSHIELD VISOR ASSEMBLY Bracket visor R. H Bracket visor L. H Screw (/"-0 x /" special head) Shakeproof lockwasher (/") Rivet (/"-0 x /" tubular special head) For cars numbered 395 to ) WINDSHIELD VISOR ASSEMBLY Screw (/"-0 x /" special head) Finish washer (No. ) Shakeproof lockwasher (/") CENTER PILLAR ASSEMBLY R. H CENTER PILLAR ASSEMBLY L. H. Trim retainer center pillar Rear door hinge pillar assembly R. H Rear door hinge pillar assembly L. H DOOR ASSEMBLY R. H. front (trimmed) DOOR ASSEMBLY L. H. front (trimmed) DOOR ASSEMBLY R. H. rear (trimmed) DOOR ASSEMBLY L. H. rear (trimmed) DOOR ASSEMBLY R. H. front (skeleton) DOOR ASSEMBLY L. H. front (skeleton) DOOR ASSEMBLY R. H. rear (skeleton) DOOR ASSEMBLY L. H. rear (skeleton) Clinch nut (No. -3 x 5/") Clinch nut (/"-0 x 5/) Front door upholstered panel R. H Front door upholstered panel L. H Rear door upholstered panel R. H Rear door upholstered panel L. H Front door hinge body half Front door hinge door half Rear door hinge R. H. body half Rear door hinge R. H. door half Rear door hinge L. H. body half Rear door hinge L. H. door half Hinge rod front door Hinge rod rear door Screw (/"-0 x /" special) Shakeproof lockwasher (/") LOCK ASSEMBLY R. H. front LOCK ASSEMBLY R. H. rear LOCK ASSEMBLY L. H. front and rear Screw (/"-0 x /" round head) Screw (/"-0 x /" oval head) Nut (/"-0 x /" square) Shakeproof lockwasher (' countersunk) Spring door lock inside cam Spring door lock inside dog Coil spring door lock inside Door safety lock assembly Key door safety lock Set screw door safety lock Handle assembly door lock outside Screw (No. -3 x 5/" oval head) Handle assembly door lock inside Screw (No. -3 x 5/" oval head) Trim retainer inside handle CENTER SECTION CENTER PILLARS DOORS DOOR HINGES DOOR LOCKS 3

25

26 ESSEX COACH BODY PARTS LIST 5 DOOR DOVETAILS AND BUMPERS BO 75 BO 7 BO 75 BO 5 BO 7 BO 75 BO 75 BO 75 BO 5 BO 75 BO 7555 BO 59 BO 0 BO 7007 BO 755 BO 755 BO 755 BO 5 BO 7553 BO BO BO 7575 BO 755 BO 755 BO 53 BO 757 BO 7593 BO 7539 BO BO 755 BO 753 BO 7557 BO 7 BO 5 BO 759 BO 7570 BO 757 BO 750 BO 75 BO BO 7509 BO 7539 BO 750 BO BO 75 BO 59 BO 7007 DOOR DOVETAIL CASE ASSEMBLY (female) Rubber bumper dovetail Retainer dovetail rubber bumper Screw (/"-0 x /" oval head) Clinch nut (/"-0 x 5/" ) Shakeproof lockwasher (/" countersunk) Door dovetail (male) Plate male dovetail Screw (/"-0 x /" oval head) Shakeproof lockwasher (/' countersunk) Striker plate door lock Screw (No. -3 x /" round head) Screw (No. -3 x 7/" round head) Shakeproof lockwasher (5/") Retainer striker plate Rubber bumper door Retainer rubber bumper Screw (/"-0 x /" oval head) DOOR CHECK DOOR CHECK ARM AND GUIDE ASSEMBLY Screw ("-0 x /" flat head) Shakeproof lockwasher (/") Pivot door check arm Bracket and spring assembly door check R. H. Bracket and spring assembly door check L. H. Screw (/"-0 x /" round head) Spring door check Retainer door check spring Anti-rattler door check arm Spring door check arm guide DOOR GLASS AND CHANNELS Door glass (not supplied; see note, page 3) Bumper door glass Retainer rear door glass bumper Retainer front door glass bumper Rivet (3/" x 5/" truss head) Rivet (3/" x 7/" tubular) Cork door glass thick Cork door glass medium Cork door glass thin Door glass top channel see weatherstrips Door glass side channel assembly (except rear door rear) Door glass side channel assembly (rear door rear) Retainer side channel ( R. F. and L. R. ) Retainer side channel (L. F. and R. R. ) Door glass bottom channel assembly R. H Door glass bottom channel assembly L. H Clinch nut (No. -3 x 5/") Clip side channel Screw (No. -3 x /" round head) Shakeproof lockwasher (3/") 3 3 BO 7577 BO BO 757 BO BO 7590 BO BO 59 BO 759 BO 7593 BO 7535 BO 7595 BO 759 BO7537 BO 7533 BO 753 BO 59 BO 753 DOOR WEATHERSTRIPS AND TRIM RETAINERS DOOR GLASS TOP WEATHERSTRIP AND RETAINER ASSEMBLY Screw (No. x /" flat head) Door glass bottom weatherstrip and retainer assembly Screw (No. x /" flat head) Front door bottom weatherstrip and retainer assembly Rivet (9/" x 3/" flat head tubular) Screw (No. -3 x /" round head) Rear door bottom weatherstrip and retainer assembly R. H Rear door bottom weatherstrip and retainer assembly L. H. Retainer rear door bottom weatherstrip Rear door pillar e x tension weatherstrip and retainer assembly R. H Rear door pillar e x tension weatherstrip and retainer assembly L. H. Retainer rear door pillar e x tension weatherstrip Retainer front door trim bottom Retainer rear door trim bottom Screw (No. -3 x / " round head) Retainer center pillar trim

27 ESSEX COACH BODY PARTS LIST DOOR WINDLACE Part. No. BO 757 BO 75 BO 5 BO 50 BO 799 BO 753 BO 59 BO 79 BO 7577 BO 59 BO BO 7007 BO BO 7570 BO 59 BO 70 BO 0 BO 75 BO 59 BO 7007 BO BO 7505 BO 5 BO 75 BO 90 BO 9 BO 9 BO 95 BO 5 BO 7339 BO 733 BO 733 BO 7337 BO 730 BO 733 CO 7599 CO BO BO BO 7555 BO 755 BO 7557 BO 7507 BO 7557 BO 59 BO 7007 BZ 799 BO 755 BO 755 BO BO 75 BO Windlace and retainer assembly (top) Windlace and retainer assembly lock pillar Screw (No. -3 x 3/3" special head) Nut (No. -3 special) Nut (No. -3 x /") Windlace and retainer front door hinge pillar Screw (No. -3 x /" round head) Nut (No. -3 x 3/" square) Windlace and retainer rear door hinge pillar Screw (No. -3 x /" round head) Screw ( t"-0 x /" special head) Shakeproof lockwasher (3/") Finish strip R. H. door top Finish strip L. H. door top Screw (No. -3 x /" round head) Screw (No. -3 x 5/" oval head) Finish washer (No. countersunk) Finish strip door center Screw (No. -3 x /" round head) Shakeproof lockwasher (3/") DOOR FINISH STRIPS DOOR WINDOW REGULATOR DOOR WINDOW REGULATOR ASSEMBLY R. H. DOOR WINDOW REGULATOR ASSEMBLY L. H. Screw (/"-0 x 3/" oval head) Shakeproof lockwasher Handle window regulator Plate window regulator handle Screw window regulator handle Washer window regulator handle Washer window regulator handle anti-rattler Spring window regulator Pinion window regulator Arm and sector assembly R. H. Arm and sector assembly L. H Roller regulator arm Pin regulator arm roller REAR HINGE PILLAR ASSEMBLY R. H. REAR HINGE PILLAR ASSEMBLY L. H Clinch nut (No. -3 x 5/") Clinch nut (/"-0 x 3/") REAR HINGE PILLAR QUARTER GLASS AND CHANNELS Quarter window glass (see note, page 3) Cork thick quarter glass Cork medium quarter glass Cork thin quarter glass Quarter window channel top see weatherstrip Quarter window channel and retainer side Spacer quarter window channel Screw (No. -3 x /" round head) Screw (No. -3 x 3/" flat head) Nut (No. -3 x /") Quarter window channel assembly bottom QUARTER WINDOW WEATHERSTRIPS REAR SECTION Quarter window weatherstrip and retainer top Screw (No. x /" sheet metal) Quarter window weatherstrip and retainer bottom Screw (No. x /" sheet metal)

28

29 ESSEX COACH BODY PARTS LIST CO BO 53 BO 7 BO 0 BO BO 753 BZ BO 7595 BO 7007 BO 755 BO 7559 BO 5 BO 75 BO 7595 BO 750 BO 9 BO 75 BO 7007 CO 779 CO 70 BO 5 BO BO 0 BO 9 BO CO 75 CO 75 BO 9 BO 53 BO 7005 BO 7 BO 5 BO 0 BO 7533 BO 750 BO 750 BO 753 BO 7535 CO 759 CO 759 BO 759 BO 759 BO 7595 BO 759 BO 7593 BO 7597 BO 759 BO 759 CO 7573 CO BO 7503 BO 75 BO 759 BO 7007 CO 70 CO 70 CO 703 CO 70 QUARTER WINDOW FRAME AND CURTAINS QUARTER WINDOW FRAME AND MOULDING ASSEMBLY Screw (/-0 x /"' round head) Screw (No. -3 x 5/" round head) Nut (/"-0 x /" square) Clinch nut (No. -3 x 3/") Quarter window curtain and roller assembly Screw (No. -3 x 3/') Cord quarter window curtains guide Velour upholstered tack QUARTER WINDOW REGULATOR QUARTER WINDOW REGULATOR ASSEMBLY R. H. QUARTER WINDOW REGULATOR ASSEMBLY L. H Screw (/"-0 x /" round head) Shakeproof lockwasher (/" countersunk) Spacer quarter window regulator Handle quarter window regulator Plate regulator handle Screw quarter window regulator handle Shakeproof lockwasher OUTSIDE PANELS AND MOULDINGS (Specify color) QUARTER PANEL AND SIDE SILL ASSEMBLY R. H. QUARTER PANEL AND SIDE SILL ASSEMBLY L. H. Screw (/"-0 x /" oval head) Rivet (No. 9 x 3/" flat head) Nut (."-0 x /" square) Nail (/" x 3/" countersunk head) Screw (No. x /" sheet metal) Back panel upper Back panel lower Nail (/" x 3/" countersunk head) Screw (/"0 x /" round head) Rivet (No. 9 x 5/" flat head) Washer (5/" x 3/" flat side) Screw (/"-0 x 7/" round head) Nut (/"-0 x /" square) Nut cage fender bracket Nut cage fender bracket Moulding rear panel horizontal Moulding rear panel vertical R. H Moulding rear panel vertical L. H REAR UPHOLSTERED PANELS Specify color) Rear quarter upholstered pane R. H. lower Rear quarter upholstered pane: L. H. lower Center pillar upholstered panel Rear pillar upholstered panel R. H Rear pillar upholstered panel L. H Quarter window to roof upholstered panel R. H Quarter window to roof upholstered panel L. H Rear corner upholstered panel R. H Rear corner upholstered panel L. H. Rear upholstered panel upper REAR WINDOW FRAME ASSEMBLY Rear window frame assembly Glass rear window (see note, page 3) Moulding assembly rear window Rear window curtain and roller assembly Cord rear window curtain Velour upholstered tack Roof rail front Roof rail rear Roof rail side R. H.. Roof rail side L. H REAR WINDOW TOP SECTION ROOF

30 ESSEX COACH BODY PARTS LIST 9 ROOF Continued BX BM 5550 BO BO 3 BO 0 BO 7397 BO 739 BO 7399 BO 700 BO 75 BO 75 BO 7555 BO 757 BO 9 BO 7579 Bolt (5/"- x -3/"hex.. head) Bolt (5/"- x -3/hex.. head) Bolt (/"-0 x -3/"hex.. head) Nut (5/"- x /" square) Nut (/"-0 x /" square) Bow No. Bow No. Bow No Bow No. Top deck Binding top deck front Moulding top deck rear Drip moulding Nail (/"-3 x 3/" countersunk) Finish plate drip moulding DOME LIGHT BO 755 BO 753 DOME LIGHT ASSEMBLY Door assembly dome lamp FLOOR SECTION CO 77 BO 7575 BO 7005 BZ BO 757 BO 753 GZ 39 BO 7007 BO BO 5 BO 77 BO 09 BO 53 BO 757 BO 0 BO 759 CO 759 CO 757 CO 75 BO 759 BO 757 BO 753 BO 7535 BO 7 BO 3 BO 79 CO 759 BO 55 BO 7 A 09 BO 7 BO 75 BO 55 BO 75 BO 753 BO 55 BO 0 BO 75 BO 55 BO 0 SEATS AND CUSHIONS (Specify color) FRONT SEAT ASSEMBLY (trimmed) (less robe rail) Support front seat front Bolt (7/"- x -/" step) Nut Support front seat side Floor bracket front seat Bolt (3/"- x -/"hex.. head) Nut (3/"- x 3/" parkerized) Rivet (3/" x 9/" button head)/ Rivet (3/" x 7/" truss head) Adjusting bolt assembly front seat rear Cap front seat adjusting bolt Nut front seat adjusting bolt Cage front seat adjusting bolt nut Adjusting bolt (only) front seat Robe rail Cushion assembly front seat Cushion assembly rear seat Cushion assembly rear seat back Dowel rear seat cushion Hinge rear seat back TOE BOARD RISER ASSEMBLY R. H TOE BOARD RISER ASSEMBLY L. H. Screw (No. -3 x 5/" round head) Clinch nut (No. -3 x 3/") Nut (No. l0-3 x 3/" square) Toe plate and accelerator rod assembly Toe plate assembly Screw (No. -3 x 5/" round head) Front floor board steel Screw (No. -3 x 5/" round head) Front floor board wood Bolt (/"-0 x -/" flat head) Center floor board R. H Center floor board L. H Bolt (/"-0 x -/" flat head) Nut (/"-0 x /" square). Rear floor board Bolt (/"-0 x -/" flat head) Nut (/"-0 x /" square) TOE AND FLOOR BOARDS

31 30 ESSEX COACH BODY PARTS LIST CARPETS, MATS AND PADS BO 750 BO 3 BO 700 BO 757 BO 7007 BO 7599 BO BO BO 757 BO 7 BO 33 BZ 799 BO 39 BO 7573 BO 757 BO 359 Rear floor carpet (specify color) Glove fastener button and drive screw Carpet fastener Heel board carpet Weaver carpet fastener Rocker carpet R. H Rocker carpet L. H Front floor rubber mat L. H. D Front floor rubber mat R. H. D Fastener socket plate Fastener socket Fastener socket nut (No. -3 x /") Fastener post Dash and floor felt pad L. H. D Dash and floor felt pad R. H. D Clincher button (3/" x -/") 5 5 I 5 SCUFF PL ATE BO 7590 BO 759 BO 759 BO 7593 BO 700 Scuff plate front R. H. Scuff plate front L. H Scuff plate rear R. H. Scuff plate rear L. H Screw (No. -3 x / oval head) I I I

32 Windshield, top and body glass for Hudson cars is not carried in stock by us. The firms listed below have been furnished with blueprints of Hudson glass, and in event of ordering from them be sure to supply the correct part number of the glass required. PITTSBURGH PLATE GLASS COMPANY WAREHOUSES Akron, Ohio Lincoln St. Albany, N. Y. Ferry and Broadway Atlanta, Ga 5-0 Alabama St. Baltimore, Md. - Paca St. Birmingham, Ala nd and 9th Sts. Boston, Mass 99-3 Portland St. Brooklyn, N. Y 3rd Ave. and Dean St. Buffalo, N. Y -7 Seneca St. Chicago, III 3-5 St. Clair St. Cincinnati, Ohio Broadway and Court Sts. Cleveland, Ohio 39 Hamilton Ave. Columbus, Ohio E. Spring St. Dallas, Texas Santa Fe Terminal Bldg. Davenport, Iowa - Scott St. Denver, Colorado 55-0 Blake St. Des Moines, Iowa ast Fourth and Vine Sts. Detroit, Mich. Hamilton and Golden Ayes. Ft. Worth, Texas 5-7 Calhoun St. Grand Rapids, Mich -3 Ionia Ave., S.W. Harrisburg, Pa. 7th and Brockwood St. High Point, N. C 3 Hamilton St. Houston, Tex. Crawford and Commerce Sts. Indianapolis, Ind. 95 Madison Ave. Jacksonville, Fla Enterprise St. Kansas City, Mo. Fifth and Wyandotte Sts. Long Island City, N. Y. 93 Hunterspoint Ave. Memphis, Tenn Madison Ave. Milwaukee, Wise 9-50 Market St. Minneapolis, Minn South Third St. Newark, N. J Elizabeth Ave. and Peddie St. New Haven, Conn Brewery St. New Orleans, La. Girod and Commerce St. Oklahoma City, Okla. - E. Grand Ave. Omaha, Nebr th and Jones Sts. Philadelphia, Pa th and Indiana Ave. Pittsburgh, Pa 3- Duquesne Way Rochester, N. Y 9 State St. St. Louis, Mo th and Spruce Sts. St. Paul, Minn 59- Jackson St. San Antonio, Texas 0- South Alamo St. Savannah, Ga Wheaton St. Shreveport, La. Fannin and Commerce Sts. Springfield, Mass Liberty St. Syracuse, N. Y So. West St. Toledo, Ohio Albion St. Tampa, Fla. 3-0 Cass St. Washington, D. C. th and Channing St. N. E. OTHER GLASS SOURCES Boise, Idaho Boise, Idaho Detroit. Michigan Fairfield, Iowa Fresno, California Lincoln, Nebraska Los Angeles, California Montreal, Canada Salt Lake City, Utah San Diego, California San Francisco, California Seattle, Washington Spokane, Washington Toronto, Canada Walla Walla, Washington Yakima, Washington Inter-Mountain Glass Co. Inc. W. P. Fuller Co. The Auto Glass Co. Thoma & Son W. P. Fuller Co. Western Paint & Glass Company W. P. Fuller Co. Consolidated Plate Glass Co. W. P. Fuller Co. W. P. Fuller Co. W. P. Fuller Co. C C. Belknap Glass Co. W. P. Fuller Co. Consolidated Plate Glass Co. W. P. Fuller Co. W. P. Fuller Co.

33